engine oil MITSUBISHI 3000GT 1996 2.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine GENERAL - Sensor Location9SENSOR
LOCATION
NameSymbol
Name
Symbol
ABS front speed sensorYKickdown servo switchM
ABS rear speed sensorZ
Knock sensorE
Air inlet sensor (for A/C)SLeft bank heated oxygen sensorD
Air therm0 sensor (for A/C)RManifold differential pressure sensor*4CAutomatic transaxle oil temperature sensor M
4lT>Photo sensor
TCamshaft
posit!on sensor and crankshaft N. . .Power steering pressure switchFposrtton sensor” I
Camshaft position sensor (from 1993 model)GPulse generator A, B <A/T>M
Crankshaft position sensor (from 1993 model)HRevolution pick-up sensorI
EGR temperature sensor*3CcTurbo, Non Turbo (for California)>Right bank heated oxygen sensorD
Engine coolant temperature sensor (for A/C)QSteering wheel angle speed sensor0
Engine coolant temperature sensorL(for engine control)Therm0 sensor*2
K
Engine coolant temperature switch (for
A/C)*2LThermostatI
Front impact sensorIx1 Throttle position sensorIJ 1
G sensor (for ABS)PJ( Vehicle speed sensor (Reed switch)*’Ip I
G sensor(for ECS)*31 Vehicle speed sensorIB 1
Heated oxygen sensor*”ID( Volume air flow sensortA 1/III
Interior temperature sensorIw II I
NOIF
I:;
:
*2:
Up to 1992 models(3)
*3:
Up to 1993 models(4)
*a:
Up to 1995 models
From 1996 models
19FO13400004237
TSB Revision

Downloaded from www.Manualslib.com manuals search engine GENERAL - How to Diagnose293. Jumper wire
A jumper wire is used to close an open circuit. Never
use one to connect a power supply directly to a load.
Z16602274. Voltmeter
A voltmeter is used to measure the circuit voltage. Normally,the positive (red lead) probe is applied to the point of
voltage measurement and the negative (black lead) probeto the body ground.
5. Ohmmeter
An ohmmeter is used to check continuity or measure resis-
tance of a switch or coil. If the measuring range has been
changed, the zero point must be adjusted before measure-
ment.
CHECKING SWITCHES
In a circuit diagram, a switch is represented by a symbol andin the idle state.
1. Normal open or normal close switch
Switches are classified into those which make the circuit
open and those which make the circuit closed when off.
INormal open (NO) typeIOFF
/4-
1X
t
Current does not flow
16X0690
ON
1
a
ia
Current flows
16X0691
00000401
Normal close (NC) type
i===ONOFF
1
/4-
1X
Current does not flow16X0690
00000402
a
III
Current flows
16X0691
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 30GENERAL - How to Diagnose
5432
1
18AO253
10W80800000403
Coil
Iron
Cover
Spring
Iron
core
- ContZt
21680231
(NO) type
Energized state1Normal op6
Deenergized state
--
nKilX
Current does not flow
lSXO804
!
Current flows10x0095000004042. SWITCH CONNECTION
This figure illustrates a complex switch. The continuity
between terminals at each position is as indicated in the
table below.4th stage
CHECKING RELAYS1. When current flows through the coil of a relay, its core
is magnetized to attract the iron piece, closing (ON) the
contact at the tip of the iron piece. When the coil current
is turned off, the iron piece is made to return to its original
position by a spring, opening the contact (OFF).
2.By using a relay, a heavy current can be turned on and
off by a switch of small capacity. For example, in the circuit
shown here, when the switch is turned on (closed), current
flows to the coil of the relay. Then, its contact is turned
on (closed) and the light comes on. The current flowingat this time to the switch is the relay coil current only
and is very small.3. The relays may be classified into the normal open type
and the normal close type by their contact construction.
NOTE
The deenergized state means that no current is flowing
through the coil and the energized state means that current
is flowing through the coil.
JI
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 46CONFIGURATION DIAGRAMS - Engine and Transaxle <M/T>
ENGINE AND TRANSAXLE <M/T>:
Connector
symbol
B
Front View
B-0: B;lO 53-11B-12R-i?
IB-06 B-07 B-08B-40*’
B-02
------+
B-01B-30
\ 7
I
B-29
- \B-:4B-23
B-25 <Turbo>
A36F0176
B-01
B-02
B-03
B-04
B-05
B-06
B-07
B-08
B-09
i*B-25 <Non-turbo>
NOTE
[:I*‘A992 models*2: From 1993 models*s:1994, 1995 models for California and from 1996 models*4: From 1996 models
Engine coolant temperature gauge unit
Engine coolant temperature sensor
Engine coolant temperature switch(for air conditioning circuit)
Crankshaft position sensor and camshaftposition
sensor*’Throttle position sensor
Control wiring harness and oil pressure wiring
harness combination
Control wiring harness and injector wiring
harness combination
Knock sensor
Variable induction servo motor
(with intake control valve position sensor)
<Non-Turbo>
B-10
B-11
B-12
B-13
B-14
B-15
B-16
B-17
B-18
B-19
B-20
B-21
B-22
Variable induction servo motor(with intake control valve position sensor)
<Non-Turbo>
Injector No. 5
Injector No. 3
Injector No. 1
Ignition coil
Capacitor
Left bank heated oxygen sensor (front)
<Turbo, Non Turbo
- 1994, 1995 models for
California and 1996 models>
Generator
GeneratorRight bank heated oxygen sensor (front)
Magnetic clutch
Power Transistor
Power TransistorL)
TSB Revision

Downloaded from www.Manualslib.com manuals search engine B-23
B-24
B-25
B-28
B-29
B-30
B-31
B-32
B-33
Rear View
B-46*4
B-32
B-33
A36F0167
Starter motor
Starter motor
Back-up light switchFuel pump relay
<Turbo>Volume air flow sensor (with intake air
temperature sensor and atmospheric sensor)
Control wiring harness and battery cable
combination
Injector No. 2
Injector No. 4
Injector No. 6
B-34
B-35
B-36
B-37
B-38
B-40
B-41
B-44
B-45B-46
Speed sensor <Turbo>
Idle air control motor (stepper motor)
Oil pressure gauge unit
Oil pressure switch
Power steering pressure switch
Camshaft position
sensor*2
Crankshaft position sensor*2Right bank heated oxygen sensor
(rear)*3Left bank heated oxygen sensor
(rear)*3Manifold differential pressure
sensor*4
CONFIGURATION DIAGRAMS - Engine and Transaxle <M/T>47
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 48CONFIGURATION DIAGRAMS - Ennine and Transaxle <A/T>
ENGINE AND TRANSAXLE <A/T>
Front View
By ‘-[ i”i 7741e2
B-06 B-07 B-06 *\ I I /A /
B-05\ \IB-30
-
B-04*’B-03
-
B-02B-01
-
B-29
*B-24A36F0176
/ m \ i-42*2
B-20I
1IB-27 B-26*’ B-26*2 B-43*2
NOTE
[:I 1:: zif ~$$‘~ode~s
(3) l ?1994, 1995 models for California and from 1996 models
(4)
*4:From 1996 models
B-01
B-02
B-03
B-04
B-05
B-06
B-07
B-08
B-09
Engine coolant temperature gauge unit
Engine coolant temperature sensor
Air conditioning engine coolant temperature switch
Crankshaft position sensor and camshaftposition
sensor*’
Throttle position sensor
Control wiring harness and oil pressure wiring
harness combinationControl wiring harness and injector wiring
harness combination
Knock sensor
Variable induction servo motor(with intake control valve position sensor)
B-10
B-11
B-12
B-13
B-14
B-15
B-16
B-17
B-l 8
B-l 9
B-20
B-21
Variable induction servo motor
(with intake control valve position sensor)
Injector No. 5
Injector No. 3
Injector No. 1
Ignition coil
CapacitorLeft bank heated oxygen sensor
(front)*3
Generator
Generator
Right bank heated oxygen sensor (front)
Magnetic clutch
Power transistor
I-- ~~~TSB Revision

Downloaded from www.Manualslib.com manuals search engine B-22
B-23
B-24
B-26
B-27
B-29
B-30
B-31
B-32
B-33
B-34
Rear View
B-46*4 B-328~33
CONFIGURATION DIAGRAMS - Engine and Transaxle <A/T>49 ~
I
A36F0169
Power transistor
Starter motor
Starter motor
Inhibitor switchELC-4
A/T control solenoid valve
Volume air flow sensor (with intake air
temperature sensor and atmospheric sensor)Control wiring harness and battery cable
combination
Injector No. 2Injector No. 4
Injector No. 6
Speed sensor
B-35
B-36
B-37
B-38
B-40
B-41
B-42
B-43
B-44
B-45
B-46
Idle air control motor (stepper motor)
Oil pressure gauge unit
Oil pressure switch
Power steering pressure switch
Camshaft position
sensor*2
Crankshaft position sensor*2
Kickdown servo switch*2AA fluid temperature
sensor*2Right bank heated oxygen sensor
(rear)*3Left bank heated oxygen sensor
(rear)*3
Manifold differential pressure sensor*4
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 58CONFIGURATION DIAGRAMS - Luaaaae Compartment
LUGGAGE COMPARTMENTpIl --.
<HATCHBACK>-
F-11
F-12
F-13
F-14
F-15F-F-16
F-34
NOTE
(1) l ‘:From 1993 mod
[;I I’,: Up to 1994 models-_
: Up to 1993 models
F-01
F-02
F-03
F-04
E-05
F-06
F-07
F-08
F-09
F-l 0
F-11
F-12
F-l 3
F-14
F-15
F-l 6
F-17
F-l 8
F-l 9
F-20
Interior temperature sensor
Defogger
(+)
Rear wiper motorHigh-mounted stop light or active aero rear
spoiler
Defogger (-)
Rear speaker (RH)
ECS rear shock absorber (RH)
Luggage compartment lightABS resistor
<FWD>
Rear combination light (RH)
Back-up light (RH)
ECS control unit
ECS control unit
Body wiring harness (RH) and fuel tank wiring
harness combination
Rear washer motor
Fuel tank
License plate light (RH)Body wiring harness (RH) and rear bumper
wiring harness combinationBody wiring harness (LH) and body wiring
harness (RH) combinationBody wiring harness (LH) and body wiring
harness (RH) combination
F-21
F-22
F-23
F-24
F-25
F-26
F-27
F-28f-29
F-30
F-31
F-32
F-33
F-34
F-35
F-36
F-37
F-38
F-39
F-40
License plate light (LH)
Luggage compartment light switch
Liftgate cylinder lock switch
Liftgate switch
Back-up light (LH)Active exhaust control
unit*2Active aero control unit
Active aero control unit
Active exhaust actuator
assembly*2
Rear combination light (LH)
Motor antenna control unit
ECS rear shock absorber (LH)
Rear speaker (LH)Body wiring harness (LH) and
liftgate wiring
harness combinationBody wiring harness (LH) and
liftgate wiring
harness combination
Telephone
cable*3
Spare connector (Wireless telephone unity3
Spare connector (Hand free
controller)*3
Jumper connector (or Hand free controller)*3CD
changer*’
1 TSB Revision
I
‘id ~~
I
II~
I
LJ

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit71
I
/
2B-Y>:5IOD OR
%iMOR
1
B-W
I2B-W
.ENGINECONTROL MODULE.IGNITION COIL.IGNITION POWERTRANSISTOR,MFI RELAY
'REMOTECONTROLLED
MIRROR
.&~[E"~ORY
.ETACS UNITL
TRANSAXLE
f%m"
I
*tf@'$ESS CONTROL
.REAR
INTERMITTENT
WIPER RELAY.AUTO-CRUISECONTROL UNIT.WASHER MOTOR.ETACS UNIT.WIPER MOTOR.MOTOR ANTENNA.WIPER RELAYCONTROL UNIT$~~CJ&~AND TAPE:ABS
POWER RELAY.CONDENSOR 7
(UP TO 1993 October)AiFAyOTOR
.BACK UP LIGHT.LIGHT AUTOMATICSHUT-OFF UNIT
G~GAERoCONTROL UNIT.SPARECONNECTOR+J;&~L"U'SE
MAIN SWITCH(#&i;iE).AIR CONDITIONINGCOMPRESSOR LOCK
CONTROLLER$&JTR.INIC
SUSPENSION.AIR CONDITIONINGCONTROL UNITCONTROL UNIT*RADIATOR*&L"$R MOTORFAN MOTOR
RELAY
.#&lyCRUISE
$i$&NATION$$;NATION
.ETACS UNIT.MOTOR ANTENNACONTROL UNIT
.SPEED SENSbR.ggTDIAGNOSI~
.TURN SIGNALAND HAZARD
FLASHER UNIT.BLOWER MOTORRELAYCHI)
REMARKTHE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THEIGNITION KEY POSITION "ACC", "ON" AND "ST" COMBINED.BE SURE TRACE THE APPROPRIATE CIRCUIT DEPENDING ON THEIGNITION KEY POSITION.
0 (c-59) (c-70) (c-82)
~giJJ~jq$q
LHROlMOOBB
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit75
IGNITION3y; 6
SWITCH
(c-59)
I
IGlVI
2B-YpL52B-W *2L-BIOD OR%ii&!OR
II
B-W
JGENERATOR7RELAY__-_--_-_____-___-_____________
2B-W
.ENGINECONTROL MODULE.IGNITION COIL.IGNITION POWERTRANSISTOR.MFI RELAYTRANSAXLE
ki8%EL
f
,BACK UP LIGHT.LIGHT AUTOMATICSHUT-OFF UNIT$$~TDIAGNOSIS
I$
'ABSPOWER RELAY(UP TO 1993 October).AIR CONDITIONINGCOMPRESSOR LOCK
CONTROLLER
.AIR CONDITIONINGCONTROL UNIT'&#R MOTOR
.BLOWER MOTORRELAYCHI)
.--_--
.&EE;qORY
.ETACS UNIT
+ L-l'#fiBi;'"
.REMOTECONTROLLED
MIRROR
+jjf$ESS CONTROLic
.REARINTERMITTENT
WIPER RELAY
.WASHER MOTOR.WIPER MOTOR.WIPER RELAY
.AUTO-CRUISECONTROL UNIT.ETACS UNIT.MOTOR ANTENNACONTROL UNIT.RADIO ANDTAPE PLAYER.ACTIVE AERO\
CONTROL UNIT.SPARECONNECTOR$@RC~UISE
MAIN SWITCH(jiifb%E)
~f$J&CRUISE.SPEED SENSOR
~'$@~NATION$/$TDIAGNOSIS
.&y&NATION.TURN SIGNALAND HAZARD
FLASHER UNIT
.ETACS UNIT.MOTOR ANTENNACONTROL UNIT
T
REMARKTHE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THE
IGNITION KEY POSITION "ACC","ON" AND "ST" COMBINED.
BE SURE TRACE THE APPROPRIATE CIRCUIT DEPENDING ON THE
IGNITION KEY POSITION.
HROlMOlBB
TSB Revision